选型注意事项

  S7-300PLC的选型原则是据生产工艺所需的功能和容量进行选型，并考虑维护的方便性、备件的通用性，以及是否易于扩展和有无特殊功能等要求。选型时具体注意以下几方面：

  (1)有关参数确定。一是输入/输出点数(I/O点数)确定。这是确定PLC规模的一个重要依据，一定要根据实际情况留出适当余量和扩展余地。二是PLC存储容量确定。注意当系统有模拟量信号存在或要进行大量数据处理时，其存储容量应选大一些。

  (2)系统软硬件选择。一是扩展方式选择，S7-300PLC有多种扩展方式，实际选用时，可通过控制系统接口模块扩展机架、Profibus-DP现场总线、通信模块、运程I/O及PLC子站等多种方式来扩展PLC或预留扩展口;二是PLC的联网，包括PLC与计算机联网和PLC之间相互联网两种方式。因S7-300PLC的工业通信网络淡化了PLC与DCS的界限，联网的解决方案很多，用户可根据企业的要求选用;三是CPU的选择，CPU的选型是合理配置系统资源的关键，选择时必须根据控制系统对CPU的要求(包括系统集成功能、程序块数量限制、各种位资源、MPI接口能力、是否有

  PROFIBUS-DP主从接口、RAM容量、温度范围等)，并好在西门子公司的技术支持下进行，以获得合理的选型;四是编程软件的选择，这主要考虑对CPU的支持状况，我们的体会是：STEP7V4.0对有些型号的CPU不支持，硬件组态时会发生故障出错，而STEP7V5.0则不存在这种问题。

  二、设计及使用注意事项

  1. 设计注意事项

  设计时主要应注意以下几方面：

  (1)PLC输出电路中没有保护，因此在外部电路中应设置串联熔断器等保护装置，以防止负载短路造成PLC损坏。熔断器容量一般为0.5A。

  (2)PLC存在I/O响应延迟问题，因此在快速响应设备中应加以注意。MPI通信协议虽简单易行，但响应速度较慢。

  (3)编制控制程序时，好用模块式结构程序。这样既可增强程序的可读性，方便调试和维护工作;又能使数据库结构统一，方便WinCC组态时变量标签的统一编制和设备状态的统一显示。

  (4)硬件资源。要合理配置硬件资源，以提高系统可靠性。如PLC电源配电系统要配备冗余的UPS不间断电源，以排除停电对全线运行的不利影响。又如对电机的控制回路要进行继电器隔离，以消除外部负载对I/O模块的可能损坏。另外，系统设备要采用独立的接地系统，以减少杂波干扰。

ALLEN BRADLEY 1492-CB2H100 CIRCUIT BREAKER ***NIB***

Lot 5 Allen Bradley Relays Contactors 100-A09ND3 3169

50 Allen Bradley Carbon Comp Resistors 100k 1/2W 5% 

Lot (4) Allen Bradley 100-C23*10 Contactor w/ relay S3

Allen Bradley SLC 100 w/ expansion unit

100 Allen Bradley Carbon Comp Resistors 100k 1/2W 5% 

Lot (9) Allen Bradley 100-C23*10 Contactor S3

Allen Bradley PLC SLC-100/150 1745-PCC cable (7ft)

ALLEN BRADLEY 100-B25ON*3 CONTACTOR 3 PHASE 600 VAC MAX

Allen-Bradley 100-C12EJ10 24V DC HZ 13 Contactor NEW

ALLEN BRADLEY 1336S-BRF100-AA?-EN4 SER E AC DRIVE

2098-DSD-HV100-?SE Allen Bradley 2098DSDHV100SE 

ALLEN BRADLEY 100-B110N*3

FACTORY SEALED ALLEN BRADLEY 100S-C60D14C CONTACTOR

Allen Bradley Contactor 100-C12Z*10 Series A

Allen Bradley Contactor Starter 100 B180N*3 _ 208V Coil

LOT 3 ALLEN BRADLEY 100-C09*10 & 193-EA1DB CONTR. & REL

ALLEN BRADLEY 100-B110ND3 USPP 100B110ND3

ALLEN BRADLEY 140-MN-0630 100-C09*10 STARTER CONTACTOR

Allen Bradley 1756-EN2T -EtherNet 10-100M Comm Mod

ALLEN BRADLEY 100S-C30UDJ13BC USPP 100SC30UDJ13BC

100-B180ND3 Allen Bradley Contactor 

Allen Bradley PLC SLC-100/150 USB 1745-PCC

Allen Bradley User's Manual 1745 SLC 100 Book Guide

100 Ohm 2W 5% Carbon Comp ALLEN BRADLEY resistor 25 ea.

ALLEN BRADLEY 100-A45N*3 STARTER *

Allen Bradley Bar Code Reader Wedge Access 2755-CE100

ALLEN BRADLEY 1492-W4 LOT OF 100 PCS TERMINAL BLOCK NEW

LOT OF 3 ALLEN BRADLEY CONTACTORS 100-A18NO2 12-05 L-1

Allen Bradley Resistors 100 pieces

ALLEN BRADLEY SIZE 4 STARTER 509-EOD 509-E0D 120V 100HP

Allen-Bradley 100-ETA30, Electronic Timing Module

Allen Bradley 100-C60*00 100C6000 Contactor NEW 110V 

Allen Bradley Panel Mount Disconnect 1494F-N100 100 A

Allen Bradley Panel Mount Disconnect 1494V-DS100 100 A

Allen Bradley 1745-E101 1745E101 SLC 100 Expansion Unit

Allen-Bradley 100-A18ND3 AC Contactor

Allen Bradley 1398-DDM-005 | Ultra 100 Servo Drive

Allen Bradley Starter Auxillary 100-DNY42S **NIB**

Allen Bradley 100-D110 Contactor Non Reversing F1

Allen Bradley AB Starters IEC Bulletin 100-C37D10

ALLEN-BRADLEY SLC 1745-PT1 PROGRAMMER FOR 100/150 PLC

Allen Bradley PLC SLC-100/150 1745-PCC cable (12ft)

4 ALLEN-BRADLEY 1492-CB2G100 10-AMP CIRCUIT BREAKERS 

ALLEN BRADLEY BAR CODE DECODER 100-240VAC 2755-DD1A

ALLEN BRADLEY 1492-CB1 1492-CB1G100 10 AMP CB

Allen Bradley 100-C30Z*00 Contactor Complete Device

ALLEN-BRADLEY 100S-C30D14C GUARD MASTER 110V COIL

ALLEN-BRADLEY CONTACTOR 24 VDC DIODE #100-C09DJ400

ALLEN-BRADLEY CONTACTOR 24 VDC DIODE #100-C09DJ400

ALLEN BRADLEY 100-C37-00/100-?C37*00 CONTACTOR **XLNT** 

ALLEN-BRADLEY CONTACTOR 24 VDC DIODE #100-C09DJ400

ALLEN BRADLEY 100A 500L-DOD93 115-120V COIL CONTACTOR 

ALLEN-BRADLEY CONTACTOR 24 VDC DIODE #100-C09DJ400

ALLEN-BRADLEY CONTACTOR 24 VDC DIODE #100-C09DJ400

ALLEN BRADLEY 100-SB10 AUXILIARY CONTACT BLOCK

ALLEN-BRADLEY CONTACTOR 24 VDC DIODE #100-C09DJ400

Allen Bradley AB IEC Contactor 100-C23D10 

Allen Bradley Contactor 100-C16D10 16AMP 3POLE 120VAC

Allen Bradley 100-B180N*3 3Pole Contactor 225Amp 600VAC

Allen Bradley AB Starters IEC Bulletin 100-C16D10

Allen Bradley 100-A75N*3 3P Contactor 100A 600V 110-120

ALLEN BRADLEY 100-C23D300 CONTACTOR NEW IN BOX

Allen Bradley Contactor 100-C72*00 3P 100A 600V 110-120

Allen Bradley 100-A75N*3 3P Contactor 100A 600V 110-120

Allen Bradley 100 Ohm 2 W Linear Taper Potentiometer

Allen Bradley Non-Reversing Contactor 9A 100-C09D10

Allen Bradley 100-M09NZ243 CONTACTOR 24V 100-M09N*3

Allen Bradley Non-Reversing Contactors 100-C09D10 Pair

Allen Bradley Contactor 9amp 100-A09NJ3 

Allen Bradley AB Starters IEC Bulletin 100-C43D10

ALLEN BRADLEY BREAKER 1492-CB2 G100 10 AMP 2 POLE

Allen Bradley 100-C09DJ10 Contactor 100C09DJ10 NEW

A-B Allen Bradley 1745-DEMO-1 SLC 100 P.C. PLC Trainer

Allen Bradley 100A45NC3 Contactor 

5 Allen Bradley Carbon Comp Resistors 100k 1/2W 5% 

Allen Bradley 85 Amp Contactor 100-C85D10 Used (3124)

Allen Bradley AB Starters IEC Bulletin 100-C09D10

Allen Bradley Circuit Breaker 1492-CB3H100 NIB (3008)

Allen Bradley 85 Amp Contactor 100-C85D10 Used (3124)

Allen Bradley 100-C12D10 Contactor

Allen-Bradley 100-B11ON*3 Contactor S10

Used/Remanufact?ured Allen Bradley 1336F-BRF100-AN?-EN

ALLEN BRADLEY 1336F DRIVE, 1336F-BRF-100-A?A-EN, PARTS

Allen Bradley 100-C09*10 Control Relays - Lot of 8 

Allen-Bradley 100-A09NB3 AC Contactor New in Box!

lot Allen Bradley Contactors 100-C09Z*10

Allen Bradley Lighting Contactor Bul 100L-C20ND4 NNB

Allen Bradley SLC 100 Processor Unit 1745-LP101 PLC

3-ALLEN BRADLEY 100 SERIES CONTACTORS (GOOD CONDITION)

Allen Bradley Contactor 100-C85 85amp 24vdc coil

Allen Bradley SLC 100 150 Trainer Tool Crib Kit 1745PCC

Allen Bradley 100C43*00

Allen Bradley SLC 100 PLC Programmable Controller

ALLEN-BRADLEY 1745-TCAT CONTROL UNIT,SLC-100,15?0,KEY 

Allen Bradley 100-B250N*3

Allen-Bradley-M?anual Starter & Contactor-Cat.#?140 &100 

Allen Bradley AB Starters IEC Bulletin 100-C09ZJ10

ALLEN BRADLEY 1336F-CWF100-AN?-EN AC DRIVE

ALLEN BRADLEY DRIVE 100-HP 1336F-B100-AA-E?N-HCS2-LA1-L6

ALLEN BRADLEY 100-C43D00 CONTACTOR 115VAC COIL***XLNT**

1492-CB1G100 Allen Bradley 1492CB1G100 1492-CB1-G100

Allen Bradley Safety Contactor 100-D140 100S-D140D22C

Allen Bradley 10A 1-Pole Circuit Breaker 1492-CB1-G100

Allen Bradley 9A Contactor, 100-C09KD10

Allen Bradley 100-A60ND3 Ser. C Contactor 60 amp

Allen Bradley 100-M09N*3 /A 100-M09 Contactor

Allen Bradley 100-C09*10 Contactor S3

ALLEN BRADLEY 100-A09ND3 W/193-A1E1 RELAY

Allen Bradley AB Starters IEC Bulletin 100-C60D10

Allen Bradley Contactor 100-A18ND3 C Relay 193-BSC 10 B

Allen Bradley 100-K09KJ10 Mini Contactor

 ALLEN BRADLEY CONTACTOR 100-A24NZ*3 115-VDC NIB

Allen Bradley 100-A18NKD3 AC Contactor Relay; *C2

Allen Bradley 100-FSD250 surge suppressors (2)

Allen Bradley 100k 5% 1/4watt Carbon Comp 50pc

ALLEN BRADLEY A31 MOTOR CONTACTOR AUXILLIARY 100-F 

Allen Bradley 100 amp 3P Circuit Breaker 140M-I8 NEW 

Allen Bradley 100-C12EJ10 Contactor 24VDC 100C12EJ10

Allen Bradley 100-C23Z*10 30A Motor Contactor C23

ALLEN BRADLEY AB TERMINAL BLOCKS 1492-J3 (LOTS OF 100)

ALLEN BRADLEY CONTACTOR Model 100 C09D

ALLEN BRADLEY 1492GH100 CIRCUIT BREAKER 10AMP 125VAC

ALLEN BRADLEY 100-M05NZ*3 100-M05NZ243 Mini Contactor 

ALLEN BRADLEY CONTACTOR 100-B180N3 120V COIL 150HP 600V

ALLEN BRADLEY 100-C12*10 A CONTACTOR 12AMP 240VAC 3-POL

Allen Bradley 10A 2-Pole Circuit Breaker 1492-CB2-H100

ALLEN BRADLEY 1494V-H1 OPERATING HANDLE 30,60,100AMP 

ALLEN BRADLEY 100-C37ZJ10 37 AMP 3 POLE CONTACTOR

Allen Bradley 100-A60N*3 60 Amp Contactor A60 Motor

Allen-Bradley 100-C09*10 Contactor

ALLEN BRADLEY Carbon Comp Resistor 100k 2 watt 10% (1)

ALLEN BRADLEY 100-A12ND3 STARTER 193-BSB42 OVERLOAD 

1492-GH100 ALLEN BRADLEY SINGLE POLE CIRCUIT BREAKER

ALLEN BRADLEY CONTACTOR 100-A12ND3 OVERLOAD 193-BSB16

 Allen Bradley Contactor 100-C09DJ10

Allen-Bradley 1492-CB1 Manual Motor Controller G100

ALLEN-BRADLEY 100 OHM CARBON COMP RESISTORS 50-1/4 Watt

Allen Bradley Contactor 100-MO5N*3 SER A M05 10E (3454)

Allen Bradley 1492-GH100 Series B Style GH AMP Breaker

ALLEN BRADLEY 24 VDC RELAY SERIES B 100-A30NZ 3 

Allen Bradley AB Starters IEC Bulletin 100-C30D10

NEW Allen Bradley Contactor 100-C12D10

Allen Bradley Contactor 100-C60D*00 Series B

ALLEN BRADLEY Contactor # 100-C09D10 Ser A - New!

Allen Bradley 100-C72* Contactor 100-C7200

Allen Bradley RCR 100k 5% 1/4watt Carbon Comp 50pc

ALLEN BRADLEY 100 AMP MOTOR CONTACTOR 100-C72*00 C72B00

Allen Bradley 100-A18ND3 Series C Unit

Allen Bradley 100-C12D10 Ser. A Contactor

Allen Bradley 100-C12*10 /A 100-C12 Contactor

ALLEN BRADLEY (1494V-H1) A 100A OPERATING HANDLE NEW

Allen Bradley Contactor 100-A09NZ*3 24VDC w O/relay

ALLEN BRADLEY 100-A09NZ*3 CONTACTOR 9 A 600V 24VDC COIL

ALLEN BRADLEY 194R-NJ100P3 DISCONNECT SWITCH FUSED 

ALLEN BRADLEY 100-C30Z D10 100-S B CONTACTOR

Allen Bradley Contactor 100-A09ND3 120/110 VAC (3570)